2024 Gillig Low Floor Recalls, Complaints & Specs
9 safety recalls list the 2024 Gillig Low Floor. Check your own VIN below.
- 1997
- 1998
- 1999
- 2000
- 2001
- 2002
- 2003
- 2004
- 2005
- 2006
- 2007
- 2008
- 2009
- 2010
- 2011
- 2012
- 2013
- 2014
- 2015
- 2016
- 2017
- 2018
- 2019
- 2020
- 2021
- 2022
- 2023
- 2024
- 2025
- 2026
9 safety recalls for the 2024 Gillig Low Floor
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Labels (equipment)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses equipped with Michelin X InCity Grip D rear tires. The rear Gross Axle Weight Rating (GAWR) on the federal placard may exceed the tire load rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120,…
Remedy: Gillig will replace the federal placard, free of charge. Owner notification letters are expected to be mailed April 24, 2026. Owners may contact Gillig customer service at 1-800-735-1500.
-
Hoses, lines/piping, and fittings (fuel system)
Gillig, LLC (Gillig) is recalling certain 2021-2026 Low Floor transit buses. The air compressor intake pipe may contact and damage the fuel line.
Remedy: Gillig will inspect, replace, and reorient the intake pipe as necessary, free of charge. Owner notification letters were mailed April 24, 2026. Owners may contact Gillig's customer service at 1-800-735-1500.
-
Cables (electrical system)
Gillig, LLC (Gillig) is recalling certain 2023-2026 Low Floor transit buses. The high voltage cable, connecting the inverter to the drive unit, contains a splice connection that reduces the amp capacity rating.
Remedy: Gillig will reprogram the software as an interim repair. For the final remedy, Gillig will replace the high voltage cable. Both repairs will be provided free of charge. Owner notification letters are expected to be…
-
Traction battery (electrical system)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The high voltage batteries may have loose hardware that can fall inside the battery pack and create a short circuit.
Remedy: Gillig will install new battery fasteners as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
-
Tv/radio/speakers (equipment)
Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.
Remedy: Gillig will replace the rivet-nut fasteners, free of charge. Owner notification letters were mailed March 18, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
-
Equipment: wiring and relays/solenoids (electrical system)
Gillig, LLC (Gillig) is recalling certain 2021-2024 Low Floor style transit buses. The fire suppression relay cable may be damaged, chafing against the mounting bolt, and fail.
Remedy: Dealers will replace the relay cable, free of charge. Owner notification letters were mailed December 31, 2024. Owners may contact GILLIG customer service at 1-800-735-1500.
-
Interlock/lockout (electrical system)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor style transit buses. The high voltage electric air compressor may not be connected to the High Voltage Interlock Loop (HVIL). Therefore, the HVIL cannot detect a loose or disconnected compressor power cable.
Remedy: Dealers will install an additional electrical harness, extending the HVIL loop to the air compressor, free of charge. Owner notification letters were mailed February 12, 2025. Owners may contact GILLIG customer service…
-
Windshield wiper/washer (visibility)
Gillig, LLC (Gillig) is recalling certain 2024 Low Floor buses. A defective welded joint may cause the wiper arm to suddenly fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 104, "Windshield Wiping and Washing Systems."
Remedy: Gillig will replace the wiper motor arm, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact Gillig customer service at 1-800-735-1500.
-
Critical fasteners (steering)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The steering spline shaft fasteners may have been improperly tightened, allowing the steering spline shaft to loosen.
Remedy: Gillig will tighten the fasteners, free of charge. Owner notification letters were mailed August 13, 2024. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
No owner complaints on file
NHTSA has no owner complaints on file for the 2024 Gillig Low Floor. For context, the average model year in NHTSA's database has dozens; a zero can mean a reliable vehicle, a rare one, or both.
Compare Gillig Low Floor model years
Recall and complaint counts for every Gillig Low Floor model year in NHTSA's database.
Checking a specific 2024 Gillig Low Floor
How do I know if my 2024 Gillig Low Floor has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 9 campaigns currently list the 2024 Gillig Low Floor; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Gillig dealer with your VIN and the NHTSA campaign number (for example 24V514000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Gillig models
- 29 Foot Low Floor1 complaints
- Phantom1 complaints
- School Bus1 complaints
- 35 and 40 Foot Low Floor0 complaints
- 568150 complaints
- 855150 complaints
- Brt0 complaints
- Bus0 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.