1994 Chevrolet C30 Recalls, Complaints & Specs

7 safety recalls list the 1994 Chevrolet C30, and owners have filed 7 complaints with NHTSA. Check your own VIN below.

• 1967
• 1970
• 1971
• 1973
• 1974
• 1975
• 1976
• 1977
• 1978
• 1979
• 1980
• 1984
• 1985
• 1986
• 1987
• 1988
• 1989
• 1990
• 1991
• 1992
• 1993
• 1994
• 1995
• 1996
• 1997
• 1998

7 safety recalls for the 1994 Chevrolet C30

Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.

1. Switch (exterior lighting)

   NHTSA 99V025000 Reported February 5, 1999 988,587 vehicles potentially affected GENERAL MOTORS CORP.

   Vehicle description: pickup trucks, crew cabs, utility trucks and sport utility vehicles. These vehicles were built with the polarity of the wiring for the zero adjust brake switch reversed from what was specified on the switch drawing. With the reversed polarity, the contacts in the brake switch can wear out prematurely. The brake…

   Remedy: Dealers will replace the brake switch and reverse the wiring.

2. Seats

   NHTSA 95V246000 Reported December 21, 1995 675,661 vehicles potentially affected GENERAL MOTORS CORP.

   The seat recliner to seat frame attaching bolts on these vehicle could loosen, fatigue and fracture, allowing the seat back to suddenly recline.

   Remedy: Dealers will remove all foam and/or fabric sandwiched between the recliner assembly and the seat frame, install washers between the seat recliner and the seat frame at each attachment point, and install new attaching…

3. Seat belts: front

   NHTSA 95V241000 Reported December 13, 1995 630,099 vehicles potentially affected GENERAL MOTORS CORP.

   If both the lap-belt and shoulder-belt energy management loops on the front seat belt assemblies release at or near the same time, acceleration forces can cause the buckle release mechanism to activate and allow the buckle to separate from the latch.

   Remedy: Dealers will remove the stitching that creates the energy management loop in the shoulder belt(s).

4. Seat belts: front

   NHTSA 95V242000 Reported December 13, 1995 40 vehicles potentially affected GENERAL MOTORS CORP.

   These vehicles were built with front seat belt systems with no energy management loops and may not meet the head injury criteria requirements of FMVSS no. 208, "occupant crash protection."

   Remedy: Dealers will replace the retractor portion of the seat belt assembly(s) with one having the newly designed energy-management twin-loop system.

5. Suspension: lower arm

   NHTSA 94V060000 Reported April 5, 1994 30,148 vehicles potentially affected GENERAL MOTORS CORP.

   Trucks were assembled with the left-hand lower control arm to frame rear nut tightened below the specified torque. Low torque on this nut may allow the attachment bolt to loosed and subsequently fatigue and break. The bolt breakage can cause the left hand control arm to separate from the frame.

   Remedy: Dealers will tighten the left-hand lower control arm to frame rear nut to the proper torque specification.

6. Seats

   NHTSA 93V216000 Reported December 14, 1993 1,375 vehicles potentially affected GENERAL MOTORS CORP.

   The seats have been assembled without bolts that connect the upper slave hinge to the seat back frame, or without bolts that connect the seat to the seat adjuster. In either case, the vehicles fail to conform to fnvss no. 207, "seating systems."

   Remedy: Dealers will inspect seats for missing bolts and install bolts if required.

7. Pedals and linkages (service brakes)

   NHTSA 93V152000 Reported September 15, 1993 70,154 vehicles potentially affected GENERAL MOTORS CORP.

   The brake pedal push rod retainer is missing, mispositioned or not properly seated.

   Remedy: Inspect vehicles to assure the brake pedal push rod retainer is present and fully seated in its correct position.

7 owner complaints filed with NHTSA

Owners of the 1994 Chevrolet C30 have filed 7 complaints with NHTSA. The average mileage at failure in those reports is 64,073 miles. Complaints peaked in 1997 with 3 filed that year.

Most-reported components

• Service brakes, hydraulic: antilock/traction control/electronic limited slip2
• Fuel system, diesel1
• Fuel system, gasoline: fuel injection system1
• Fuel system, other: fuel pump1
• Service brakes, hydraulic: foundation components1
• Service brakes, hydraulic: hoses, lines/piping, and fittings1
• Structure: tailgate1

What owners are reporting

“Electronic diesel injection pump failure and replacement 09/29/97 milage 64073 electronic diesel injection pump failure and replacement 04/30/98 milage 77903 electronic diesel injection pump failure a”

Owner complaint to NHTSA, July 10, 2003 · Fuel system, other

“Brakes locked up and truck slid on the road in the rain. *ak”

Owner complaint to NHTSA, November 3, 1997 · Service brakes, hydraulic

Compare Chevrolet C30 model years

Recall and complaint counts for every Chevrolet C30 model year in NHTSA's database.

Checking a specific 1994 Chevrolet C30

Other Chevrolet models

• Malibu19,364 complaints
• Silverado 150018,029 complaints
• Impala10,434 complaints
• Tahoe10,032 complaints
• Equinox9,161 complaints
• Silverado8,799 complaints
• Blazer8,192 complaints
• Suburban8,164 complaints

Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.