Country Coach Allure Recalls & Complaints by Model Year
NHTSA lists 22 safety recalls and 18 owner complaints across 14 model years of the Country Coach Allure (1996–2009). The most-complained-about year is 1999.
Pick your Country Coach Allure model year
What Country Coach Allure owners complain about
Across all model years, owners have filed 18 complaints with NHTSA. The 1999 model year has the most, with 4.
All Country Coach Allure recalls (22)
Every NHTSA safety campaign that lists a Country Coach Allure, most recent first, with the model years each one covers.
-
Diesel (engine and engine cooling)
Country coach is recalling certain motor homes equipped with caterpillar c9 diesel engines. The fuel pump outlet check plug may be cracked which could cause fuel to spray and leak.
Remedy: Country coach is working with caterpillar (please see 08e042). Caterpillar will replace the fuel pump plug free of charge. The recall is expected to begin during july 2008. Owners may contact caterpillar at…
-
Diesel (engine and engine cooling)
On certain motor homes equipped with caterpillar c9 diesel engines, a fuel pump failure will dilute the engine oil with fuel and may cause the turbocharger to fail and cause loss of throttle control with warning.
Remedy: Country coach is working with caterpillar to have the fuel pump replaced free of charge (please see 07e053). Owners may contact caterpillar at 309-675-6496 or country coach at 541-998-3720.
Model years: 2008
-
Recreational vehicle/trailer (equipment)
On certain motor homes equipped with atwood sealed burner ranges, the range and slide-in burner tubes leading from the gas manifold to the burner heads had a depression or 'kink' in the exterior bend restricting proper airflow and gas mixture.
Remedy: Country coach is working with atwood to have the tubes replaced on these ranges. The recall began on may 3, 2007. Owners may contact atwood at 1-800-348-7418 or country coach at 1-800-547-8015.
-
Diesel (engine and engine cooling)
On certain motor homes built with cummins isl cm850 diesel engines, the connecting rod contains a machining defect in the wrist pin bushing of the rod that could cause a seizure of the piston pin.
Remedy: Country coach is working with cummins to recalibrate the engine control module and enhance the engine protection system enabling it to provide early detection of the failure mode and avoid more serious engine damage…
-
Exterior lighting
Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard (FMVSS) no. 108, "lamps, reflective devices, and associated equipment." these motor homes were equipped with more than three amber identification lamps located at the top and front of the vehicle. Also, the side marker lights in the…
Remedy: Dealers will remove the two extra identification lamps and install four side marker lights, one at each corner, free of charge. The recall is expected to begin on or about march 31, 2008. Owners may contact country…
-
Recreational vehicle/trailer (equipment)
Certain motor homes equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Remedy: Country coach will be working with dometic in order to repair these refrigerators (please see 06e076). A secondary burner housing will be installed free of charge. The recall began on march 28, 2007. Owners may contact…
-
Tires
Country coach has reported that the toyo 275/70r m102z tires on certain motor homes are defective and could fail unexpectedly.
Remedy: Dealers will replace these tires with michelin 275/70r xza2 tires. The federal tire labels will also be replaced. The recall began on november 8, 2006. Owners may contact country coach at 1-800-547-8015.
-
Pressure monitoring and regulating systems (tires)
Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for motor vehicles other than passenger cars.' the front and rear tire cold tire inflation pressures of 125 PSI exceed the manufacturer's recommended maximum cold inflation pressure of 120 PSI.
Remedy: Country coach will issue replacement federal tire labels reflecting the corrected cold tire inflation pressure of 120 PSI for both the front and rear tires. This change will result in a reduction of the cold inflation…
Model years: 2005
-
Equipment
On certain class a motor homes equipped with vehicle systems' aqua-hot and hydro-hot water heaters, which use webasto burner tubes, the burner tubes do not meet specifications and could fail prematurely.
Remedy: Vehicle systems is conducting the owner notification and remedy for this campaign. Owners may contact vehicle systems at 1-800-685-4298 or country coach at 1-800-547-8015.
-
Recreational vehicle/trailer (equipment)
On certain motor homes, liquid propane (lp) gas cook tops were installed using a flexible rubber hose that could burn or melt.
Remedy: Dealers will replace the cook top rubber hose with copper tubing. The recall began on november 8, 2004. Customers can contact country coach at 1-541-998-3720.
Model years: 2004
-
Fuses and circuit breakers (electrical system)
On certain motor homes, a circuit breaker in the clearance light circuit does not protect the circuit from a too high amperage draw caused by a towed passenger vehicle.
Remedy: Dealers will replace the defective circuit breakers. The recall began on november 8, 2004. Customers can contact country coach at 1-541-998-3720.
Model years: 2005
-
Steering
On certain motor homes equipped with an independent front suspension (ifs) gen ii built by holland USA, the gear plate support gussets were removed. This can allow the plate to flex during a static steer condition.
Remedy: Holland USA is conducting the owner notification and remedy for this campaign. A bolt-on strengthening of the steering gear plate with u-bolts connecting the cross member to each side of the gear plate at the rear plus…
-
Latch (latches/locks/linkages)
On certain motor homes, the striker plate of the storage bay compartment door latch is positioned in proximity to the release mechanism located on the face of the slide cargo tray frame.
Remedy: Dealers will install two (2) pull handles, a latch extension, and a warning label on each affected slide tray. The recall began on august 27, 2004. Owners should contact country coach at 1-800-547-8015.
-
Recreational vehicle/trailer (equipment)
On certain motorhomes equipped with international thermal research (itr)hurricane hot water heaters, the electronic control board may adversely affect safety features in some of the systems protecting against overheating and potential fire situation.
Remedy: The defective electronic control board will be replaced. In the meantime, customers should turn the system off using the master on/off switch located on the side of the electronic control box which is adjacent to the…
-
Labels (equipment)
Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." these motor homes were erroneously assigned inadequate cold tire inflation pressures and inadequate axle weight ratings on the front and/or rear axles as a…
Remedy: Dealers will replace the front and/or rear tires. In some instances, the motor homes may only have an inadequate fawr and/or rawr stated on the federal tire label and only the federal tire label will be replaced. Owner…
-
Accelerator pedal (vehicle speed control)
Vehicle description: motor homes equipped with electronic throttle control/accelerator pedals supplied by williams controls industries. The weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
Remedy: Dealers will replace these pedals. Owner notification is expected to begin during december 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy…
Model years: 2002
-
Compressor (service brakes)
Vehicle description: motor homes equipped with cummins isc and isl diesel engines. The internal front bushing can spin, causing damage to the air compressor, and possibly to the spindle drive at the rear face of the air compressor which is used to provide power to the vehicle hydraulic pump. Failure of the air compressor's spindle drive…
Remedy: Cummins will notify country coach customers and replace the air compressor free of charge. Owner notification began march 30, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date…
-
Labels (equipment)
Certain motor homes fail to comply with requirements of FMVSS no. 120, "tire selection and rims for motor vehicles other than passenger cars." these vehicles have an inequitable weight distribution between the front left and right tires on the front axle. This weight inequity can cause the left front tire weight rating to be exceeded.
Remedy: Dealers will replace the height control valves and the height control valve configuration reversed to remedy this noncompliance. Owner notification began may 14, 2001. Owners who take their vehicles to an authorized…
-
Service brakes, air
Vehicle description: motor homes. These motor homes fail to comply with requirements of FMVSS no. 121, "air brake systems." these vehicles were assigned an inadequate front axle weight rating (fawr). As a consequence, the front brake canisters and slack adjusters do not comply with the standard requirements.
Remedy: Dealers will inspect the front brake canisters and replace them if necessary. Owner notification began march 15, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not…
-
Slack adjusters (service brakes)
Vehicle description: motor homes equipped with 15" (widths: 4" and 5") air-actuated q-plus cam brake equipped with federal mogul friction products 3030-197 brake lining (meritor r201) brake linings and actuated with type 20 air chambers x 5.5" slack adjusters. These assemblies do not fully satisfy the test performance requirements of…
Remedy: The brake lining will be replaced with upgraded brake linings.
Model years: 1999
-
Labels (equipment)
Vehicle description: motor homes equipped with slide galley option. The certification labels do not show the proper tire pressures. These pressures are below the required pressure for load carrying capacity.
Remedy: New labels with the correct inflation pressure specifications will be provided to owners. Owners will be instructed to adjust the tire pressure specifications to the new correct requirements.
-
Electrical (equipment)
The "o" rings of the regulator assembly in the onan emerald and marquis brand generator sets can weaken and break when exposed to high ambient temperatures.
Remedy: Owner notification will be conducted by onan. Dealers will either remove the lpg regulator and replace it with a model not subject to rupture, or install a pre-regulator in the fuel system.
Model years: 1996
Other Country Coach models
- Intrigue20 complaints
- Inspire14 complaints
- Magna14 complaints
- Affinity3 complaints
- Max2 complaints
- Mpv2 complaints
- Affinity Grande Chalet1 complaints
- Country Coach1 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.