2000 Orion V Recalls, Complaints & Specs
6 safety recalls list the 2000 Orion V, and owners have filed 1 complaint with NHTSA. Check your own VIN below.
6 safety recalls for the 2000 Orion V
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Pedal/hand lever(motorcycle) (power train)
Daimler buses is recalling certain orion transit buses equipped with the morse remote throttle control. The morse remote throttle control panel is located in the engine compartment and a switch on it is labeled, "throttle"; "off" or "front" and "on" or "rear" selecting the active engine control station. If a person operating the engine…
Remedy: Daimler will provide instructions to modify the wiring to the morse throttle control switch. This service will be performed free of charge. The safety recall began on april 1, 2010. Owners may contact daimler buses at…
-
Equipment adaptive/mobility
Daimler buses is recalling certain model year 2000 through 2008 orion transit buses equipped with lift-u wheelchair lifts. The lifts are equipped with a logic board assembly for the wheelchair lift control box, p/nos. 373-0226 and 373-0265. The outboard ramp barrier could fold in toward a lift passenger and pinch, press, or crush the…
Remedy: Orion will notify owners and the repairs will be made by lift-u free of charge. Please see lift-u's defect report 09e-051. The safety recall began on october 29, 2009. Owners may contact lift-u at 1-209-838-2400 or…
-
Hydraulic power assist system (steering)
On certain transit buses equipped with eaton power steering pumps, the port plug on the pump was incompletely sealed and leakage of the hydraulic fluid can occur which could result in a reduction in the power steering assist.
Remedy: Eaton is conducting the owner notification and remedy for this campaign. Dealers will replace the power steering pumps free of charge. Owners may contact eaton at 1-888-258-0222 or orion bus at 905-403-7832.
-
Structure
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." during subsequent closing of an emergency exit the moving window frame interferes with the jam frame stop located in mid span along the lower edge of the window frame.
Remedy: Dealers will install two aluminum blocks each attached by two screws. The moving window frame will not interfere with the jam frame stop. The recall began may 1, 2005. Owners should contact orion at 905-403-7832, ext.…
-
Glass, side/rear (visibility)
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." the handle pull force exceeds the 89n force to release the emergency window. Additional force is required to release the window.
Remedy: Dealers will repair these windows. Owner notification began june 1, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable…
-
12v/24v/48v battery (electrical system)
Vehicle description: transit buses equipped with vanner 60 series battery equalizers. The equalizer could fail to operate properly and cause malfunction of the battery charging system.
Remedy: Orion will notify owners to inspect their buses for certain equalizers by the date code. The affected equalizers will be replaced by vanner. Owners who take their vehicles to an authorized dealer on an agreed upon…
1 owner complaint filed with NHTSA
Owners of the 2000 Orion V have filed 1 complaint with NHTSA. Complaints peaked in 2003 with 1 filed that year.
Most-reported components
What owners are reporting
“April 21, 2003 u.s. Department of transportation national highway traffic safety administration office of defects investigation nsa-10.01, 400 7th street, sw washington, DC 20590 subject: anti-lock br”
Owner complaint to NHTSA, April 21, 2003 · Service brakes, air
Compare Orion V model years
Recall and complaint counts for every Orion V model year in NHTSA's database.
| Model year | Recalls | Complaints |
|---|---|---|
| 1990 Orion V | 1 | 0 |
| 1991 Orion V | 1 | 0 |
| 1992 Orion V | 2 | 0 |
| 1993 Orion V | 2 | 0 |
| 1994 Orion V | 3 | 0 |
| 1995 Orion V | 6 | 0 |
| 1996 Orion V | 9 | 0 |
| 1997 Orion V | 8 | 0 |
| 1998 Orion V | 11 | 0 |
| 1999 Orion V | 7 | 0 |
| 2000 Orion V | 6 | 1 |
| 2001 Orion V | 5 | 0 |
| 2002 Orion V | 6 | 1 |
| 2003 Orion V | 7 | 0 |
| 2004 Orion V | 7 | 0 |
| 2005 Orion V | 5 | 0 |
| 2006 Orion V | 4 | 0 |
| 2007 Orion V | 5 | 0 |
| 2008 Orion V | 5 | 0 |
Checking a specific 2000 Orion V
How do I know if my 2000 Orion V has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 6 campaigns currently list the 2000 Orion V; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Orion dealer with your VIN and the NHTSA campaign number (for example 01V033005).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Orion models
- VI4 complaints
- I2 complaints
- Orion2 complaints
- VII2 complaints
- II0 complaints
- Orion V0 complaints
- Orion VII0 complaints
- Orion VII Li-Ion Ess0 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.