2010 Ford Fusion Recalls, Complaints & Specs
11 safety recalls list the 2010 Ford Fusion, and owners have filed 5,130 complaints with NHTSA. At least one recall carries a do-not-drive or park-outside advisory. Check your own VIN below.
11 safety recalls for the 2010 Ford Fusion
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Inflator module (air bags)
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high…
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and…
-
Inflator module (air bags) and air bags: frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may…
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may…
-
Service brakes, hydraulic: control unit/module
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing…
-
Inflator module (air bags) Do not drive
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A."…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February…
-
Inflator module (air bags)
Ford Motor Company (Ford) is recalling certain 2010 Ford Fusion, Mercury Milan and 2010-2012 Lincoln MKZ vehicles that previously received a replacement passenger air bag under recall 16V-384, 17V-024 or 18V-046. In the event of a crash requiring deployment of the passenger air bag, the bracket that secures the air bag inflator to the…
Remedy: Ford will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began November 21, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this…
-
Inflator module (air bags) Do not drive
Ford Motor Company (Ford) is recalling certain 2013 Ford Mustang vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally,…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Owners may contact Ford…
-
Inflator module (air bags) Do not drive
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida,…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters…
-
Auxillary tank (fuel system)
Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2010. The affected vehicles have fuel vapor canisters whose purge valves may not operate properly resulting in abnormal…
Remedy: Ford will notify owners, and dealers will update the vehicle powertrain control modules and inspect the vehicle for any diagnostic trouble codes (DTCs) for this issue and perform a leak test on the Canister Purge Valve…
-
Lugs/nuts/bolts/studs (wheels)
Ford is recalling certain model year 2010-2011 ford fusion and mercury milan vehicles equipped with 17 inch steel wheels and built from april 1, 2009, through april 30, 2009, and from december 1, 2009, through november 13, 2010. The wheel studs may fracture, potentially causing a wheel to separate.
Remedy: Ford will notify owners, and dealers will inspect the rear brake disc surface for flatness and replace the discs as necessary. Additionally, the wheel lug nuts will be replaced on all four wheels. The safety recall is…
-
Automatic transmission (power train)
Ford is recalling certain model year 2010 fusion, milan, and escape vehicles manufactured from february 27, through march 26, 2010. The park rod guide retention pin may not have been properly installed which fails to conform to the requirement of federal motor vehicle safety standard no. 114, "theft protection and rollaway prevention".
Remedy: Ford will notify owners and dealers will repair the vehicles free of charge. The safety recall began on may 28, 2010. Owners may contact ford motor company customer relationship center at 1-866-436-7332 and for the…
-
Recliner (seats)
Ford is recalling certain model year 2010 fusion, explorer, explorer sport trac, and mercury milan and mountaineer vehicles manufactured between december 15, 2009 through february 3, 2010 equipped with front seat manual recliners. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 202, "head…
Remedy: Dealers will replace the manual recliners for both power and manual seats free of charge. The safety recall is expected to begin on or before april 30, 2010. Owners may contact ford at 1-866-436-7332.
5,130 owner complaints filed with NHTSA
Owners of the 2010 Ford Fusion have filed 5,130 complaints with NHTSA; 122 describe a crash and 9 describe a fire. Reports cite 74 injuries and 1 death. The average mileage at failure in those reports is 80,442 miles. Complaints peaked in 2013 with 1,169 filed that year.
Most-reported components
What owners are reporting
“My brakes felt mushy for a couple days. Next day br a ke fluid dash light came on. brake fluid was so low couldn't see it. Went to autozone bought brake fluid .dot 3 per internet. Internet went on to”
Owner complaint to NHTSA, September 22, 2026 · Service brakes
“We have had multiple issues with the ABS and HCU since we bought this car used a couple years ago. We've replaced the ABS Module and HCU and had Ford reprogram it and are still having issues. The brak”
Owner complaint to NHTSA, September 19, 2026 · Service brakes
Fuel economy and specs
EPA ratings for the 2010 Ford Fusion (Fusion AWD, Fusion AWD FFV, Fusion FWD, Fusion FWD FFV, …). Ranges cover every tested configuration.
| Combined | 19–39 mpg |
|---|---|
| City / Highway | 17–41 / 24–36 |
| Fuel | Gasoline or E85, Regular |
| EPA class | Midsize Cars |
| Engine | 4/6 cyl, 2.5/3/3.5 L |
| Transmission | Automatic (S6); Automatic (variable gear ratios); Automatic 6-spd; Manual 6-spd |
Compare Ford Fusion model years
Recall and complaint counts for every Ford Fusion model year in NHTSA's database.
| Model year | Recalls | Complaints |
|---|---|---|
| 2006 Ford Fusion | 4 | 730 |
| 2007 Ford Fusion | 4 | 1,064 |
| 2008 Ford Fusion | 5 | 1,353 |
| 2009 Ford Fusion | 6 | 1,022 |
| 2010 Ford Fusion | 11 | 5,130 |
| 2011 Ford Fusion | 7 | 2,787 |
| 2012 Ford Fusion | 5 | 2,516 |
| 2013 Ford Fusion | 19 | 1,791 |
| 2014 Ford Fusion | 19 | 1,330 |
| 2015 Ford Fusion | 13 | 994 |
| 2016 Ford Fusion | 13 | 1,636 |
| 2017 Ford Fusion | 4 | 1,112 |
| 2018 Ford Fusion | 2 | 442 |
| 2019 Ford Fusion | 3 | 315 |
| 2020 Ford Fusion | 3 | 183 |
Checking a specific 2010 Ford Fusion
How do I know if my 2010 Ford Fusion has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 11 campaigns currently list the 2010 Ford Fusion; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Ford dealer with your VIN and the NHTSA campaign number (for example 10V161000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Ford models
- F-15037,961 complaints
- Explorer34,566 complaints
- Escape27,430 complaints
- Focus22,096 complaints
- Taurus18,159 complaints
- Windstar14,158 complaints
- Edge14,065 complaints
- Expedition9,359 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.