Volvo Vah Recalls & Complaints by Model Year
NHTSA lists 20 safety recalls and 1 owner complaint across 19 model years of the Volvo Vah (2007–2026). The most-complained-about year is 2023.
Pick your Volvo Vah model year
What Volvo Vah owners complain about
Across all model years, owners have filed 1 complaint with NHTSA. The 2023 model year has the most, with 1.
All Volvo Vah recalls (20)
Every NHTSA safety campaign that lists a Volvo Vah, most recent first, with the model years each one covers.
-
Arm (steering)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VOLVO VAH, VN, VHD, 2026-2027 VNL (4) and VNR (4) vehicles. The steering knuckles may have been manufactured with insufficiently tightened steering arms.
Remedy: Dealers will inspect and tighten the fasteners between the steering arm and steering knuckle, as necessary, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Volvo Trucks'…
Model years: 2026
-
Lugs/nuts/bolts/studs (wheels) Do not drive
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VAH, 2026-2027 VN, VHD, VNL (4), and 2027 VNR (4) vehicles. The wheel lug nuts may loosen and allow the wheel to detach.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will inspect the wheel and hub mating surfaces, remove any masking material, and replace any worn components if necessary,…
Model years: 2026
-
Anchorage (seat belts)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2026 VAH trucks. The passenger seat belt anchor may fail due to inadequate floor reinforcement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Remedy: Dealers will install a new weld nut and washer, free of charge. Owner notification letters were mailed December 16, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for…
-
Software (electrical system) and service brakes, hydraulic: control unit/module
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Truck's number for this recall…
-
Motor (visibility)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2024 VNR, VNL, VHD, and VAH trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
Remedy: Dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed November 1, 2023. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks number…
-
Critical fasteners (steering)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN, VHD, and VAH trucks. The steering gear fasteners may not be properly tightened.
Remedy: Dealers will tighten the steering gear fasteners, free of charge. Owner notification letters are expected to be mailed August 18, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks'…
-
Hub (wheels) and hubcap/cover (wheels)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.
Remedy: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.
-
Critical fasteners (service brakes)
Volvo Trucks North America (Volvo Trucks) is recalling 2021 VNL, VNR, VAH, and VHD vehicles. The collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing. As a result, the brass fitting may completely release the air brake line from the pass-through plate…
Remedy: Volvo Trucks will notify owners, and dealers will inspect the air brake line for proper engagement of the fitting in the pass-through plate, free of charge. The recall is expected to begin January 31, 2021. Owners may…
Model years: 2021
-
Service brakes, air
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VAH, VHD, VNL and VNR vehicles. The die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121,…
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the pedal plates if required, free of charge. The recall began October 7, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552.…
-
Fuses and circuit breakers (electrical system)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VAH, VHD, VNL, and VNR vehicles. The fuse in the transmission circuit may blow, preventing the transmission from shifting.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the fuse, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo…
-
Automatic transmission (power train)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2020 VAH, VHD, VNL, and VNR vehicles. The t-bolt clasps on the transmission auxiliary air tank straps may have been over-tightened, resulting in potential deformation to the strap where the t-bolt is anchored.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the air tank strap, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at…
-
Fifth wheel assembly (trailer hitches)
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VNL and VNM trucks manufactured June 21, 2010, to December 14, 2012. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may…
Remedy: Volvo will notify owners, and Fontaine dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 23, 2015. Owners may contact Volvo customer service at…
-
Headlights (exterior lighting)
Volvo Trucks North America (Volvo) is recalling certain model year 2015-2016 VAH and VHD trucks manufactured April 1, 2014, to August 14, 2015. The affected vehicles may be equipped with headlights that do not meet the minimum intensity requirements, resulting in insufficient illumination of the roadway. As such, these vehicles fail to…
Remedy: Volvo will notify owners, and dealers will replace the headlights, free of charge. The recall began on January 19, 2016. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is…
-
Connection (steering)
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2016 VAH trucks manufactured January 31, 2011, to June 25, 2015, and equipped with a sealed drag link. In the affected trucks, the draglink ball socket boot may be damaged due to the angle of the ball stud. A damaged boot may allow contaminants to enter and corrode…
Remedy: Volvo will notify owners, and dealers will replace the drag link with one that has an improved geometry, free of charge. The recall began on October 13, 2015. Owners may contact Volvo customer service at…
-
Tires
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.
Remedy: Volvo will notify owners, and dealers will replace the tires and set the road speed limiter, free of charge. The recall began on January 16, 2015. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's…
-
Caliper (service brakes)
Volvo Trucks North America (Volvo) is recalling certain model year 2014-2015 VAH, VNL, and VNM trucks manufactured March 4, 2013, to April 28, 2014. Due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach from the backing plate.
Remedy: Volvo will notify owners, and dealers will inspect and tighten the bolts to specification, as necessary, free of charge. The recall began October 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.…
-
Seat belts
Volvo Trucks North America (Volvo) is recalling certain model year 2014 VAH, VHD, VNL, and VNM trucks manufactured August 12, 2013, through November 14, 2013; and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the…
Remedy: Volvo will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on January 27, 2014. Owners may contact Volvo at 1-336-393-2000. Volvo's number for…
Model years: 2014
-
Exhaust system (engine and engine cooling)
Fontaine Modification (Fontaine) is recalling certain model year 2011-2013 Volvo VAH vehicles modified with upward facing exhaust diffusers for use as auto-haulers. In the affected vehicles, heat from the exhaust may transfer to the roof of the truck cab and/or the vehicles above the cab.
Remedy: Fontaine will notify owners and dealers will replace the diffuser with one of a different shape and design, free of charge. Owners may contact Fontaine at 1-800-366-8246.
-
Visibility/wiper
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2012 VAH, VHD, VNL, and VNM trucks manufactured February 1, 2010, through September 30, 2010 and June 1, 2011, through November 30, 2011. The windshield wiper motor may fail.
Remedy: Volvo will notify owners and dealers will replace the windshield wiper motor, free of charge. The recallbegan on December 6, 2013. Owners may contact Volvo at 1-336-393-2000. Volvo's recall number is RVXX1304.
-
Clutch assembly (power train)
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the…
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Other Volvo models
- XC901,528 complaints
- S601,266 complaints
- S80954 complaints
- V70933 complaints
- XC60651 complaints
- S70593 complaints
- 850569 complaints
- S40491 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.