2023 Thomas Built Buses Saf-T-Liner Hdx Recalls, Complaints & Specs
8 safety recalls list the 2023 Thomas Built Buses Saf-T-Liner Hdx. Check your own VIN below.
- 2002
- 2003
- 2004
- 2005
- 2006
- 2007
- 2008
- 2009
- 2010
- 2011
- 2012
- 2013
- 2014
- 2015
- 2016
- 2017
- 2018
- 2019
- 2020
- 2021
- 2022
- 2023
- 2024
- 2025
- 2026
8 safety recalls for the 2023 Thomas Built Buses Saf-T-Liner Hdx
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Hoses/lines/piping/fittings (engine and engine cooling)
Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2026 Saf-T-Liner EFX and Saf-T-Liner HDX school buses. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
Remedy: Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number…
-
Hoses/lines/piping/fittings (engine and engine cooling)
Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2025 Saf-T-Liner EFX and 2023-2026 Saf-T-Liner HDX vehicles. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
Remedy: Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number…
-
Roof and pillars (structure)
Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Remedy: Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for…
-
Body (structure)
Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2023 Thomas Built Saf-T-Liner HDX school buses. The rear exterior side-body panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint…
Remedy: Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed November 11, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number…
-
Engine control module (ecu/ecm) (engine and engine cooling)
Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Thomas Built Saf-T-Liner HDX and Saf-T-Liner C2 school buses. The engine control module (ECM) may experience an internal short-circuit, which can result in an unexpected engine shut down.
Remedy: Cummins will replace the ECM, free of charge. Owner notification letters are expected to be mailed September 26, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-949.
-
Mid/rear assembly (seats) and seats
Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.
Remedy: Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is…
-
Cables (electrical system)
Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX school buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.
Remedy: Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for…
-
Cables (electrical system)
Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX commercial buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.
Remedy: Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for…
No owner complaints on file
NHTSA has no owner complaints on file for the 2023 Thomas Built Buses Saf-T-Liner Hdx. For context, the average model year in NHTSA's database has dozens; a zero can mean a reliable vehicle, a rare one, or both.
Compare Thomas Built Buses Saf-T-Liner Hdx model years
Recall and complaint counts for every Thomas Built Buses Saf-T-Liner Hdx model year in NHTSA's database.
Checking a specific 2023 Thomas Built Buses Saf-T-Liner Hdx
How do I know if my 2023 Thomas Built Buses Saf-T-Liner Hdx has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 8 campaigns currently list the 2023 Thomas Built Buses Saf-T-Liner Hdx; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Thomas Built Buses dealer with your VIN and the NHTSA campaign number (for example 22V271000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Thomas Built Buses models
- Saf-T-Liner C222 complaints
- C28 complaints
- FS-654 complaints
- Mvp-Ef4 complaints
- Ef2 complaints
- Hdx2 complaints
- Minotour2 complaints
- Saf-T-Liner ER2 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.