2004 Setra S417 Recalls, Complaints & Specs
10 safety recalls list the 2004 Setra S417, and owners have filed 1 complaint with NHTSA. Check your own VIN below.
10 safety recalls for the 2004 Setra S417
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Glass, side/rear (visibility)
Setra is recalling certain model year 2003-2010 s417 and model year 2011 s417 tc motor coaches for failing to comply with the requirements of federal motor vehicle safety standard no. 205, "glazing materials." the partition glass behind the driver of each affected bus does not have the necessary DOT markings as specified and was not…
Remedy: Dealers will replace the partition glass free of charge. The safety recall is expected begin during may 2011. Owners may contact setra at 1-800-882-8054.
-
Labels (equipment)
Setra is recalling 490 my 1984-2001 s215, my 1994-2002 s217 and my 2003-2009 s417 motor coaches equipped with emergency exits. These motor coaches fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." when a release mechanism is not located within…
Remedy: Dealers will send labels with a service instructions explaining the location of the labels free of charge. The recall is expected to begin during march 2009. Owners may contact setra at 1-800-882-8054.
-
Electrical system: wiring
On certain motor coaches, the electrical wiring harness located behind the rear toilet was not properly installed. As a result, rubbing can occur on the outside wire insulation causing the insulation to wear away and eventually cause subsequent arcing.
Remedy: Dealers will check the wiring harness routing and will change the damaged wires. In addition the wiring harness will be relocated in such a way as to prevent rubbing. The recall began on may 18, 2007. Owners may…
-
Electrical system
On certain motor coaches, the electrical wire preparation for the control of solar roof hatches was not carried out properly. This wiring may contain open energized wire ends located in the harness.
Remedy: Dealers will send out technicians to disconnect the power to the wires and reroute the wires properly free of charge. The recall began on may 18, 2007. Owners may contact setra at 1-800-882-8054.
-
Diesel (engine and engine cooling)
On certain motor coaches equipped with detroit diesel series c-60 engines, the electronic control module (ECM) will require to be reprogrammed to current mainframe calibrations.
Remedy: Detroit diesel is conducting this recall (please see 06e019000) and will reprogram the ECM to current mainframe calibrations free of charge. Owners may contact detroit diesel at 313-592-3708 or setra at 905-403-7807.
-
Suspension: control arm
On certain motor coaches, the transverse control arm of the front axle might break as a result of extreme pressure (e.g., during a sudden application of the brakes at the final stage of the stop).
Remedy: Setra technical representatives will contact the customer to set up an appointment to test the transverse control arm and, if necessary, will replace the transverse control arm free of charge. The recall began on june…
-
Indicator light (parking brake)
Certain (36-58 passenger) motor coaches fail to comply with the requirements of federal motor vehicle safety standard no. 101, "controls and displays." the parking brake indicator lamp illuminates in green and not red, when the parking brake is engaged.
Remedy: Dealers will install appropriate software to change the color of the parking brake indicator lamp from green to red free of charge. The recall began on may 24, 2005. Owners may contact setra at 1-800-882-8054.
-
Indicator light (parking brake)
On certain 36-58 passenger motor coaches, the parking brake indicator light on the dashboard may illuminate in limited circumstances even though the parking brake is not engaged.
Remedy: Dealers will replace the parking brake pressure switch free of charge. The recall on may 24, 2005. Owners may contract setra at 1-800-882-8054.
-
Storage (fuel system)
On certain motor coaches, under some conditions, cracks and fissures can form on the lower sections of the tanks' side walls, leading to fuel leakage.
Remedy: Dealers will inspect and replace the fuel tanks. Owner notification began on may 28, 2004. Owners should contact setra at 1-800-882-8054.
-
Electrical system
Certain motor coaches fail to comply with the requirements of federal motor vehicle safety standard no. 101, "controls and displays." the illumination of the controls for the hazard warning signal, heating/air-conditioning fan, and windshield defrosting and defogging system has only one level of brightness and is not adjustable. The…
Remedy: Setra technicians will go to customer locations and replace the control switch. This recall began april 6, 2004, with phased completion dates. Owners who take their vehicles to an authorized dealer on an agreed upon…
1 owner complaint filed with NHTSA
Owners of the 2004 Setra S417 have filed 1 complaint with NHTSA. The average mileage at failure in those reports is 200 miles. Complaints peaked in 2005 with 1 filed that year.
Most-reported components
What owners are reporting
“2004 ski-doo summit highmark x upon backing down from carrier left front ski snagged under loading ramp and brought the sled to a stop. Later it was noticed that the lower front a-arm had been torn fr”
Owner complaint to NHTSA, January 10, 2005 · Suspension
Compare Setra S417 model years
Recall and complaint counts for every Setra S417 model year in NHTSA's database.
Checking a specific 2004 Setra S417
How do I know if my 2004 Setra S417 has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 10 campaigns currently list the 2004 Setra S417; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Setra dealer with your VIN and the NHTSA campaign number (for example 04V091000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Setra models
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.