NHTSA Recall 04V190000: Service brakes, hydraulic: control unit/module
GENERAL MOTORS CORP. reported this safety recall to NHTSA on , covering an estimated 65,439 vehicles. It affects 2004 Chevrolet Malibu.
| NHTSA campaign | 04V190000 |
|---|---|
| Manufacturer campaign | 04030 |
| Component | SERVICE BRAKES, HYDRAULIC › ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP › CONTROL UNIT/MODULE |
| Report received | April 19, 2004 |
| Owner notification | June 16, 2004 |
| Initiated by | Manufacturer |
Defect
Some of these passenger vehicles have an electronic control unit (ECU) that may calculate a higher than actual vehicle speed because of an erratic rear-wheel speed sensor signal, and cause ABS activation where it is not needed or needed ABS activation to be extended during braking as the vehicle speed drops to about 3 MPH.
Safety risk
Unexpected ABS activiation could increase stopping distance up to about 11 feet dpending on the grade of the road, increasing the risk of a crash.
Remedy
Dealers will reprogram the ABS controller. Owner notification began on june 16, 2004. Owners should contact chevrolet at 1-800-630-2438.
Notes
GM recall no. 04030.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-DOT (1-888-327-4236).
Vehicles covered by recall 04V190000
| Make and model | Model years |
|---|---|
| Chevrolet Malibu | 2004 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.