RecallMyCar

New Flyer C30LF Recalls & Complaints by Model Year

NHTSA lists 5 safety recalls and 0 owner complaints across 5 model years of the New Flyer C30LF (2001–2005).

5
safety recalls, all years
0
owner complaints, all years
2002
year with most recalls

Pick your New Flyer C30LF model year

Model yearRecallsComplaints
2005 New Flyer C30LF20
2004 New Flyer C30LF20
2003 New Flyer C30LF10
2002 New Flyer C30LF30
2001 New Flyer C30LF20

All New Flyer C30LF recalls (5)

Every NHTSA safety campaign that lists a New Flyer C30LF, most recent first, with the model years each one covers.

  1. Interior lighting

    NHTSA 09V367000 Reported 1,412 vehicles potentially affected NEW FLYER INDUSTRIES LTD

    New flyer is recalling certain model year 2002 through 2009 transit buses manufactured between may 2002 and september 2009 equipped with luminator horizon LED side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.

    Remedy: New flyer will notify owners and repair the buses free of charge. The safety recall began on october2, 2009. Owners may contact new flyer customer services at 1-204-934-4876.

    Model years: 2002

  2. Exterior lighting

    NHTSA 07V068000 Reported 1,707 vehicles potentially affected NEW FLYER INDUSTRIES LTD

    Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." the flashing deceleration lamps were an optional item for some of these buses.

    Remedy: Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007.…

    Model years: 2001, 2002

  3. Equipment adaptive/mobility

    NHTSA 06V034000 Reported 682 vehicles potentially affected NEW FLYER INDUSTRIES LTD

    On certain transit buses, the spot welds which hold the wheelchair ramp hinge assembly together can fail allowing the ramp to separate, when deployed under load, from the bus frame.

    Remedy: Dealers will add new hardware to the hinges which will make the spot-welding redundant. The recall began on february 15, 2006. Owners may contact new flyer at 1-204-934-4874.

    Model years: 2004, 2005

  4. Fan (engine and engine cooling)

    NHTSA 05V370000 Reported 665 vehicles potentially affected NEW FLYER INDUSTRIES LTD

    On certain transit buses, hydraulic fluid can leak at the flange fitting due to improper installation procedures. Incorrect installation procedures may cause damage to the o-ring of the flange assembly, compromising the sealing capability of the o-ring.

    Remedy: New flyer will contact customers with parts and instructions on how to complete this recall. The recall began on august 30, 2005. Owners may contact new flyer at 204-934-4874.

    Model years: 2004, 2005

  5. Diesel (engine and engine cooling)

    NHTSA 03V182000 Reported 497 vehicles potentially affected NEW FLYER INDUSTRIES LIMITED

    On certain transit buses equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration may not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.

    Remedy: Dealers will replace the electronic control module calibration free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a…

    Model years: 2001, 2002, 2003

Other New Flyer models

Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.