2004 Monaco Coach Windsor Recalls, Complaints & Specs
7 safety recalls list the 2004 Monaco Coach Windsor, and owners have filed 3 complaints with NHTSA. Check your own VIN below.
7 safety recalls for the 2004 Monaco Coach Windsor
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Water heater (equipment)
On certain class a motor homes equipped with vehicle systems' aqua-hot and hydro-hot water heaters, which use webasto burner tubes, the burner tubes do not meet specifications and could fail prematurely.
Remedy: Dealers will replace the combustion chambers (burner tubes) with a new one free of charge. Owners may contact monaco at 1-800-685-6545.
-
Water heater (equipment)
On certain motor homes, the water heater exhaust on the curve side wall under the back side of the kitchen slideout room box terminates under the slide box when in the extended position. This design could create a risk of migration of carbon monoxide into the interior of the motor home.
Remedy: Dealers will replace the water heater with a 16 gallon atwood unit that has a different exhaust termination. The recall began march 25, 2005. Owners should contact monaco at 1-800-685-6545.
-
Water heater (equipment)
On certain motor homes manufactured with optional aqua hot hydronic heaters, the exhaust termination for the heater was located under the bedroom slide out, when it should have been placed beyond the periphery of the vehicle.
Remedy: For the 2003 motor homes, dealers will use the existing pipe from the aqua hot hydronic heater, and repair it so that the end termination will be to the passenger side of the motor home. For the 2004 and 2005 motor…
-
Diesel (engine and engine cooling)
On certain motorhomes equipped with cummins engines, oil can leak into the engine compartment from a crack in the cup plug.
Remedy: Cummins is conducting the owner notification and remedy for this campaign. Cummins will install a steel cup plug boss cap to all affected engines. Owners should contact cummins customer assistance center at…
-
Recreational vehicle/trailer (equipment)
Certain motor homes had a water line (thermoid value-flex/gs) installed to the aqua-hot heating system unit ("aqua hot") when a fuel line should have been used.
Remedy: Dealers will remove the incorrect water line and replace it with the correct fuel line. Owner notification is expected to begin during may or june 2004. Owners should contact monaco at 1-800-498-9478.
-
Anchorage (seat belts)
Certain motorhomes fail to comply with the requirements of federal motor vehicle safety standard no. 207, "seating systems," and no. 210 "seat belt assembly anchorages." the seat belt anchorage bolts can fail.
Remedy: Dealers will inspect the belt latch bolt and install a bushing and a grade 5 bolt. Owner notification began march 8, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do…
-
Hoses, lines/piping, and fittings (service brakes)
On certain motorhomes certification tags were omitted on the cloth covered front and rear brake line assemblies.
Remedy: Dealers will install new front and rear cloth covered brake lines that have the required certification tags. Owner notification began october 20, 2003. Owners who take their vehicles to an authorized dealer on an…
3 owner complaints filed with NHTSA
Owners of the 2004 Monaco Coach Windsor have filed 3 complaints with NHTSA; 1 describe a fire. The average mileage at failure in those reports is 53,900 miles. Complaints peaked in 2004 with 1 filed that year.
Most-reported components
What owners are reporting
“Tl* the contact owns a 2004 monaco coach windsor rv. While the motor home was parked, a puddle of fuel was discovered underneath the rear of the vehicle. The vehicle was taken to an independent mechan”
Owner complaint to NHTSA, August 2, 2019 · Fuel/propulsion system
“O4 monaco windsor with 19095 miles air breaks came on while driving, caused front brake acuator to freeze and burn out pads and disk,may have been on fire, everything charred. All unknown to driver ti”
Owner complaint to NHTSA, April 21, 2006 · Service brakes, air
Compare Monaco Coach Windsor model years
Recall and complaint counts for every Monaco Coach Windsor model year in NHTSA's database.
Checking a specific 2004 Monaco Coach Windsor
How do I know if my 2004 Monaco Coach Windsor has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 7 campaigns currently list the 2004 Monaco Coach Windsor; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Monaco Coach dealer with your VIN and the NHTSA campaign number (for example 03V360000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Monaco Coach models
- Knight54 complaints
- Diplomat48 complaints
- Cayman40 complaints
- Monaco33 complaints
- Lapalma30 complaints
- Dynasty25 complaints
- Signature13 complaints
- Camelot7 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.