RecallMyCar

2005 Itasca Sundancer Recalls, Complaints & Specs

4 safety recalls list the 2005 Itasca Sundancer, and owners have filed 1 complaint with NHTSA. Check your own VIN below.

4
safety recalls
1
owner complaint to NHTSA

4 safety recalls for the 2005 Itasca Sundancer

Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.

  1. Radio/tape deck/cd etc. (equipment)

    NHTSA 06V456000 Reported 1,491 vehicles potentially affected WINNEBAGO INDUSTRIES, INC.

    On certain motor homes equipped with front overhead televisions, incorrect fasteners were used to secure the television located in the front overhead area of the motor home.

    Remedy: Dealers will inspect the vehicle to assure the correct fasteners (bolts) were used in the tv retention strap. The recall began on december 15, 2006. Owners may contact winnebago at 1-800-537-1885.

  2. Tank assembly (fuel system)

    NHTSA 05V475000 Reported 3,613 vehicles potentially affected WINNEBAGO INDUSTRIES, INC.

    On certain motor homes built on ford chassis, the fasteners holding the fuel tank mounting straps may not have been properly tightened, allowing the possibility for the fuel tank to loosen and fall.

    Remedy: Dealers will inspect and properly tighten the fasteners to the fuel tank straps. The recall began on october 15, 2005. Owners may contact winnebago at 614-585-6939.

  3. Electrical system: wiring

    NHTSA 04V512000 Reported 3,950 vehicles potentially affected WINNEBAGO INDUSTRIES, INC.

    On motor homes built on ford e-series chassis and equipped with gas engines, a diode in the anti-lock braking system (ABS) module may experience an electrical short.

    Remedy: Ford motor company is conducting the owner notification and remedy for this campaign. Dealers will install a new fuse in the ABS circuit and install a heat shield over the ABS module. Owners should contact ford at…

  4. Engine and engine cooling

    NHTSA 04V516000 Reported 5,125 vehicles potentially affected WINNEBAGO INDUSTRIES, INC.

    On motor homes built on ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. This change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain…

    Remedy: Ford motor company is conducting the owner notification and remedy for this campaign. Dealers will inspect and replace the air filter element. Owners should contact ford at 1-800-392-3673 or winnebago at 641-585-3535.

1 owner complaint filed with NHTSA

Owners of the 2005 Itasca Sundancer have filed 1 complaint with NHTSA. The average mileage at failure in those reports is 2,500 miles. Complaints peaked in 2004 with 1 filed that year.

Most-reported components

What owners are reporting

“Regarding a model year 2005 winnebago itasca motorhome (serial no. 70467f241566c) utilizing a model year 2004 ford e450 chassis. While sleeping an alarm went off inside the mobile home. The local fire”

Owner complaint to NHTSA, November 12, 2004 · Engine and engine cooling

Compare Itasca Sundancer model years

Recall and complaint counts for every Itasca Sundancer model year in NHTSA's database.

Model yearRecallsComplaints
1987 Itasca Sundancer10
1988 Itasca Sundancer10
1989 Itasca Sundancer10
1990 Itasca Sundancer20
1991 Itasca Sundancer10
1992 Itasca Sundancer20
1993 Itasca Sundancer10
1994 Itasca Sundancer11
1995 Itasca Sundancer10
1996 Itasca Sundancer10
1998 Itasca Sundancer01
1999 Itasca Sundancer05
2000 Itasca Sundancer10
2001 Itasca Sundancer30
2002 Itasca Sundancer12
2003 Itasca Sundancer40
2004 Itasca Sundancer40
2005 Itasca Sundancer41
2006 Itasca Sundancer30

Checking a specific 2005 Itasca Sundancer

How do I know if my 2005 Itasca Sundancer has an open recall?

Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 4 campaigns currently list the 2005 Itasca Sundancer; your car may already have been repaired under some of them.

Is the recall repair free?

Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Itasca dealer with your VIN and the NHTSA campaign number (for example 04V512000).

What is the difference between a recall and a complaint?

A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.

Other Itasca models

Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.