RecallMyCar

International 9100I Recalls & Complaints by Model Year

NHTSA lists 5 safety recalls and 0 owner complaints across 6 model years of the International 9100I (2001–2006).

5
safety recalls, all years
0
owner complaints, all years
2003
year with most recalls

Pick your International 9100I model year

Model yearRecallsComplaints
2006 International 9100I10
2005 International 9100I10
2004 International 9100I10
2003 International 9100I50
2002 International 9100I30
2001 International 9100I20

All International 9100I recalls (5)

Every NHTSA safety campaign that lists a International 9100I, most recent first, with the model years each one covers.

  1. Back up lights (exterior lighting)

    NHTSA 23V353000 Reported 32,880 vehicles potentially affected Navistar, Inc.

    Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar,…

    Remedy: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number…

    Model years: 2001, 2002, 2003

  2. Equipment

    NHTSA 17V792000 Reported 10,195 vehicles potentially affected Navistar, Inc.

    Navistar, Inc. (Navistar) is recalling certain 2000-2001 International 4700, 2000-2002 4900, 2001-2003 8100 (TranStar) and 9100I, 2002-2003, 2005, 2007-2009, 2012-2014 and 2016-2018 DuraStar, 2012 and 2014-2017 ProStar, 2014-2015 TerraStar, and 2018 LT trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button…

    Remedy: Navistar will notify owners, instructing them to notify Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin February 9, 2018. Owners may contact Navistar customer service at…

    Model years: 2001, 2002, 2003

  3. Cables (electrical system)

    NHTSA 05V296000 Reported 49,607 vehicles potentially affected INTERNATIONAL TRUCK & ENGINE CORPORATION

    On certain 4x2 and 6x4 heavy duty trucks, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.

    Remedy: Dealers will inspect the vehicles to determine if any chafing has occurred between positive and negative cables. If there is no evidence of chafing, then a saddle clamp will be installed to ensure cables will not rub.…

    Model years: 2003, 2004, 2005, 2006

  4. Alternator/generator/regulator (electrical system)

    NHTSA 03V072000 Reported 881 vehicles potentially affected INTERNATIONAL TRUCK & ENGINE CORPORATION

    On certain heavy duty trucks built with a detroit engine and a leece neville alternator. The electrical terminal at the alternator end of the cable that runs from the starter to the battery stud on the alternator may break off, due to vibration in the cable.

    Remedy: Dealers will reroute and rewire the wiring harness to the alternator. Owner notification began on march 13, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive…

    Model years: 2002, 2003

  5. Hoses, lines/piping, and fittings (service brakes)

    NHTSA 02V309000 Reported 252 vehicles potentially affected INTERNATIONAL TRUCK AND ENGINE

    On certain heavy duty trucks, the bolts and locking nuts used to hold the brake spiders or brake anchor plates tight to the axles were under-torqued on the right side of the vehicles. If the clamp load on the bolts is not sufficient, the anchor plate may move when the brake is applied in either the forward or reverse direction.

    Remedy: Dealers will inspect and tighten all suspect bolts. New wheel seals and new bolts will be installed where applicable. Owner notification is expected to begin during december 2002. Owners who take their vehicles to an…

    Model years: 2003

Other International models

Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.