1995 International Harvester 3800 Recalls, Complaints & Specs
4 safety recalls list the 1995 International Harvester 3800, and owners have filed 8 complaints with NHTSA. Check your own VIN below.
4 safety recalls for the 1995 International Harvester 3800
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Antilock/traction control/electronic limited slip (service brakes)
The wiring from the electronic control unit was connected to the wrong wheel sensor or to the wrong brake modulator valve. It is possible that either or both wiring may have occurred at either the front or rear axle or both axles.
Remedy: Dealers will inspect the ABS wiring and, if necessary, properly connect.
-
Hubcap/cover (wheels)
The front wheel hub can develop cracks at the wheel mounting studs. When mounted to the hub, the hydraulic brake disc rotor does not properly support the hub at the wheel studs causing excessive stress and fatigue cracks in the hub.
Remedy: Dealers will install new, redesigned hubs on these vehicles.
-
Turbo/supercharger (engine and engine cooling)
Four compression backplate retaining fasteners on the turbo-charger were torqued only hand tight. This allows the fasteners to loosen, and causes oil to leak into the compressor air side of the turbo-charger which, when coupled with the heat precipitated by the compressor and the mixing action of the compressor wheel, can result in an…
Remedy: Replace the suspect turbo-charger with a new turbo-charger.
-
Accelerator pedal (vehicle speed control)
These buses were built with an additional 3/4 inch thick plywood floor and extra thick floor mats for increased insulation during cold weather. The bottom edge of the accelerator pedal, when depressed, can come in contact with the head of a bolt securing the transmission cover to the floor. The engine throttle may not return to the idle…
Remedy: Dealers will remove 1/2 inch from the bottom of the accelerator pedal.
8 owner complaints filed with NHTSA
Owners of the 1995 International Harvester 3800 have filed 8 complaints with NHTSA. Complaints peaked in 1999 with 6 filed that year.
Most-reported components
What owners are reporting
“We found 4 buses with cracked frames approx. 6 inches back from the shock hanger on both sides in the front. They were 95 model thomas buses on international frames, we took them out of service and se”
Owner complaint to NHTSA, October 17, 2006 · Structure
“I am a medium sized school bus fleet. We found the above vehicle has both front frame rails cracked. This defect was found during a routine pm inspection. We immediately inspected 20 other school buse”
Owner complaint to NHTSA, February 2, 2001 · Structure
Compare International Harvester 3800 model years
Recall and complaint counts for every International Harvester 3800 model year in NHTSA's database.
| Model year | Recalls | Complaints |
|---|---|---|
| 1979 International Harvester 3800 | 1 | 0 |
| 1980 International Harvester 3800 | 1 | 0 |
| 1981 International Harvester 3800 | 2 | 0 |
| 1982 International Harvester 3800 | 3 | 0 |
| 1983 International Harvester 3800 | 2 | 0 |
| 1984 International Harvester 3800 | 2 | 0 |
| 1985 International Harvester 3800 | 2 | 0 |
| 1986 International Harvester 3800 | 2 | 0 |
| 1987 International Harvester 3800 | 2 | 1 |
| 1988 International Harvester 3800 | 2 | 0 |
| 1989 International Harvester 3800 | 3 | 0 |
| 1991 International Harvester 3800 | 5 | 1 |
| 1992 International Harvester 3800 | 5 | 0 |
| 1993 International Harvester 3800 | 4 | 1 |
| 1994 International Harvester 3800 | 4 | 3 |
| 1995 International Harvester 3800 | 4 | 8 |
| 1996 International Harvester 3800 | 3 | 2 |
| 1997 International Harvester 3800 | 3 | 3 |
| 1998 International Harvester 3800 | 1 | 4 |
| 1999 International Harvester 3800 | 2 | 9 |
| 2000 International Harvester 3800 | 3 | 9 |
| 2001 International Harvester 3800 | 2 | 0 |
Checking a specific 1995 International Harvester 3800
How do I know if my 1995 International Harvester 3800 has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 4 campaigns currently list the 1995 International Harvester 3800; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised International Harvester dealer with your VIN and the NHTSA campaign number (for example 94V133000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other International Harvester models
- School Bus42 complaints
- 470040 complaints
- 490021 complaints
- International Harvester11 complaints
- Conventional10 complaints
- 94008 complaints
- 93007 complaints
- 92006 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.