2023 Autocar Xpeditor Recalls, Complaints & Specs
17 safety recalls list the 2023 Autocar Xpeditor. Check your own VIN below.
17 safety recalls for the 2023 Autocar Xpeditor
Most recent first. Recall repairs are free at any authorised dealer. Click a recall for the full defect, consequence and remedy text.
-
Electronic stability control (esc)
Autocar, LLC (Autocar) is recalling certain 2023-2026 ACX (Xpeditor) vehicles. Contact with the drive line yoke may damage the Electronic Stability Control (ESC) unit.
Remedy: Autocar will relocate the ESC unit, free of charge. Interim owner notification letters explaining the safety risk were be mailed March 27, 2026. Another notice will be sent once the remedy is available, anticipated…
-
Column (steering) and critical fasteners (steering)
Autocar, LLC (Autocar) is recalling certain 2023-2026 ACX (Xpeditor) and DC (Legend) vehicles. The steering wheel nut may be improperly secured, allowing the steering wheel to separate from the steering column.
Remedy: Autocar will inspect and secure the steering wheel nut as necessary, free of charge. Owner notification letters were mailed November 28, 2025. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's…
-
Critical fasteners (structure)
Autocar, LLC (Autocar) is recalling certain 2023-2024 ACX (Xpeditor). The retaining ring could be missing from the cab tilt hinge pin, leaving the pin unsecured.
Remedy: Dealers will inspect the cab tilt pin and replace the retaining ring as necessary, free of charge. Owner notification letters were mailed September 2, 2024. Owners may contact Autocar customer service at…
-
Axle hubs (power train)
Autocar, LLC (Autocar) is recalling certain 2023-2024 ACX (Xpeditor) and DC (Legend) vehicles. The axle lock nut may be improperly secured, allowing the wheel end to separate.
Remedy: Dealers will inspect and secure or replace the lock nut, free of charge. Owner notification letters were mailed July 26, 2024. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this…
-
Steering
Autocar, LLC (Autocar) is recalling certain 2023 ACX (Xpeditor) and ACTT (Xspotter) vehicles. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.
Remedy: Dealers will inspect and replace the steering gears as necessary, free of charge. Owner notification letters were mailed April 4, 2024. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers…
-
Lugs/nuts/bolts/studs (wheels)
Autocar, LLC (Autocar) is recalling certain 2023 ACX (Xpeditor) and DC (Legend) vehicles. The wheel lug nuts may not be tightened properly.
Remedy: Dealers will inspect and tighten the lug nuts, as necessary, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers…
-
Indicator light (parking brake)
Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2021-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Remedy: Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall are…
-
Critical fasteners (steering)
Autocar, LLC (Autocar) is recalling certain 2022-2023 ACX (Xpeditor) and 2023 DC (Legend) vehicles. The steering column shaft pinch bolt may not have been properly secured.
Remedy: Dealers will replace the steering column shaft pinch bolts, free of charge. Owner notification letters were mailed November 27, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for…
-
Center support bearing (power train)
Autocar, LLC (Autocar) is recalling certain 2023 ACX (Xpeditor) and DC (Legend) vehicles. The powertrain driveline center support bearing hardware may not have been properly secured.
Remedy: Dealers will inspect and secure or replace the powertrain driveline support bearing hardware, as necessary, free of charge. Owner notification letters were mailed October 6, 2023. Owners may contact Autocar customer…
-
Hoses, lines/piping, and fittings (fuel system)
Autocar, LLC. (Autocar) is recalling certain 2023 ACX (Xpeditor) vehicles, equipped with Cummins L9 diesel engines. The remote Stage 2 fuel filter hoses may have been damaged during production, allowing the hoses to leak or disconnect.
Remedy: Cummins dealers will replace both hoses, free of charge. Owner notification letters were mailed September 28, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is…
-
Instrument cluster/panel (electrical system)
Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2020-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these trucks fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Remedy: Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed July 31, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall is…
-
Latch (latches/locks/linkages)
Autocar, LLC (Autocar) is recalling certain 2021-2023 Autocar Xpeditor (ACX) trucks. The right-side stand-up door latch may be assembled incorrectly.
Remedy: Dealers will inspect and reassemble the door latch, as necessary, free of charge. Owner notification letters were mailed July 20, 2023. Owners may contact Autocar's customer service at 1-888-218-3611. Autocar's number…
-
Center support bearing (power train)
Autocar, LLC (Autocar) is recalling certain 2022-2023 ACX (Xpeditor) and 2020-2023 DC (Legend) vehicles. The powertrain driveline center support bearing hardware may not have been properly secured.
Remedy: Dealers will inspect, and if necessary, secure or replace the powertrain driveline support bearing hardware, free of charge. Owner notification letters were mailed May 18, 2023. Owners may contact Autocar customer…
-
Fuel gauge (electrical system)
Autocar, LLC (Autocar) is recalling certain 2021-2023 Xpeditor vehicles that run on natural gas. A software error in the instrument cluster may cause an inaccurate fuel gauge reading.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed March 22, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this…
-
Exterior lighting and structure
Autocar, LLC (Autocar) is recalling certain 2020-2023 Xpeditor vehicles. The external sun visor may obstruct the roof mounted clearance lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy: Dealers will remount roof mounted clearance lights above the sun visor. Owner notification letters were mailed December 20, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this…
-
Critical fasteners (steering) and column (steering)
Autocar, LLC (Autocar) is recalling certain 2021-2023 Autocar Xpeditor vehicles. The steering column shaft pinch bolt may be improperly secured.
Remedy: Dealers will replace the steering column shaft pinch bolt, free of charge. Owner notification letters were mailed on December 19, 2022. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number…
-
Steering
Autocar, LLC. (Autocar) is recalling certain 2022-2023 Legend, Xpeditor, and Xspotter trucks equipped with Sheppard Steering Gears. The steering gears may have been assembled incorrectly,which can cause the gear to fracture.
Remedy: Dealers with inspect and replace the steering gear, at no charge. Owner notification letters were mailed on August 29, 2022. Owners can contact Autocar's customer service at 765-489-5499. Autocar's number for this…
No owner complaints on file
NHTSA has no owner complaints on file for the 2023 Autocar Xpeditor. For context, the average model year in NHTSA's database has dozens; a zero can mean a reliable vehicle, a rare one, or both.
Compare Autocar Xpeditor model years
Recall and complaint counts for every Autocar Xpeditor model year in NHTSA's database.
Checking a specific 2023 Autocar Xpeditor
How do I know if my 2023 Autocar Xpeditor has an open recall?
Enter your 17-character VIN above. The VIN is on the driver's side dashboard (visible through the windshield), the driver's door jamb sticker, and your registration or insurance card. The check runs against NHTSA's live database and tells you which campaigns list your vehicle. 17 campaigns currently list the 2023 Autocar Xpeditor; your car may already have been repaired under some of them.
Is the recall repair free?
Yes. Under federal law, manufacturers must fix safety recalls at no charge for vehicles up to 15 years old from the date of sale to the first owner. Contact any authorised Autocar dealer with your VIN and the NHTSA campaign number (for example 22V475000).
What is the difference between a recall and a complaint?
A recall is a safety campaign filed by the manufacturer or ordered by NHTSA, with a defined defect and remedy. A complaint is a report an owner sent to NHTSA; it is not verified, but patterns of complaints are what trigger NHTSA investigations and, eventually, recalls.
Other Autocar models
- Autocar2 complaints
- Acx1 complaints
- Wx1 complaints
- Wxll1 complaints
- 103640 complaints
- 103660 complaints
- 73660 complaints
- 93640 complaints
Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.