RecallMyCar

Starcraft Ultrastar Recalls & Complaints by Model Year

NHTSA lists 4 safety recalls and 0 owner complaints across 12 model years of the Starcraft Ultrastar (2002–2013).

4
safety recalls, all years
0
owner complaints, all years
2006
year with most recalls

Pick your Starcraft Ultrastar model year

Model yearRecallsComplaints
2013 Starcraft Ultrastar10
2012 Starcraft Ultrastar10
2011 Starcraft Ultrastar10
2010 Starcraft Ultrastar30
2009 Starcraft Ultrastar20
2008 Starcraft Ultrastar20
2007 Starcraft Ultrastar30
2006 Starcraft Ultrastar30
2005 Starcraft Ultrastar10
2004 Starcraft Ultrastar10
2003 Starcraft Ultrastar10
2002 Starcraft Ultrastar10

All Starcraft Ultrastar recalls (4)

Every NHTSA safety campaign that lists a Starcraft Ultrastar, most recent first, with the model years each one covers.

  1. Labels (equipment)

    NHTSA 15V445000 Reported 800 vehicles potentially affected Starcraft Bus

    Starcraft Bus (Starcraft) is recalling certain model year 2002-2007 Allstar, Starquest, Starlite, and Ultrastar commercial buses manufactured January 1, 2002, to September 30, 2007. The affected vehicles, when loaded with passengers and fuel, may exceed the gross vehicle weight rating (GVWR). As such, these vehicles fail to comply with…

    Remedy: Starcraft will notify owners, and dealers will install a revised certification label based on corrected axle and wheel calculations or dealers will remove seats from buses that cannot support additional weight beyond…

    Model years: 2002, 2003, 2004, 2005, 2006, 2007

  2. Alternator/generator/regulator (electrical system)

    NHTSA 14V018000 Reported 1,954 vehicles potentially affected Starcraft Bus

    Starcraft Bus is recalling certain model year 2010-2013 Allstar XL, Ultrastar, Allstar, Starlite, Starquest, Xpress, Prodigy, Quest, and Allstar MVP transit buses built on Ford cutaway chassis equipped with Ford 5.4L or 6.8L engines and Trans/Air-brand air compressors. In the affected vehicles, depending on the routing of the alternator…

    Remedy: Starcraft Bus will notify owners, and dealers will inspect the vehicles, correct the clamp installation and repair and reroute the alternator harness, as needed, free of charge. The recall began on February 19, 2014.…

    Model years: 2010, 2011, 2012, 2013

  3. Equipment adaptive/mobility

    NHTSA 12V293000 Reported 2,209 vehicles potentially affected STARCRAFT BUS

    Starcraft is recalling certain model year 2006-2010 buses equipped with braun century-2 and/or vista-2 wheelchair lifts. Over time and with frequent use, the roll stop latches on the outer barrier may become bent or misaligned.

    Remedy: Starcraft will notify owners, and the repairs will be performed by authorized braun dealers free of charge. Owners may contact starcraft bus at 1-800-347-7440.

    Model years: 2006, 2007, 2008, 2009, 2010

  4. Air conditioner (equipment)

    NHTSA 11V571000 Reported 1,204 vehicles potentially affected STARCRAFT BUS

    Starcraft is recalling certain model year 2006 and 2007 transit buses built on ford and freightliner chassis and equipped with carrier genv em-1 evaporator units. Due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.

    Remedy: Starcraft will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. This service will be performed free of charge. The recall began in november 2011. (see…

    Model years: 2006, 2007, 2008, 2009, 2010

Other Starcraft models

Source: NHTSA recall and complaint databases and EPA fuel economy data, October 2026. Complaint counts are owner reports to NHTSA, not verified defects. Recall counts are safety campaigns that list this model year; whether a particular car was already repaired depends on its VIN. How this data is compiled.