NHTSA Recall 19V534000: Electrical system: module and starter assembly (electrical system)
Navistar, Inc. reported this safety recall to NHTSA on , covering an estimated 16 vehicles. It affects 2020 Ic Bus Cesb.
| NHTSA campaign | 19V534000 |
|---|---|
| Manufacturer campaign | 19512 |
| Components | ELECTRICAL SYSTEM › IGNITION › MODULE; ELECTRICAL SYSTEM › STARTER ASSEMBLY |
| Report received | July 17, 2019 |
| Owner notification | September 12, 2019 |
| Initiated by | Manufacturer |
Defect
Navistar, Inc. (Navistar) is recalling certain 2020 IC CE school buses equipped with PSI gasoline or propane engines and C7 Body Control Modules (BCM). An electrical overload condition in the BCM from the starter solenoid may occur and cause damage to the starter circuit of the BCM, possibly resulting in an unintended command to crank the engine when the ignition key is in the run position and the transmission is in the park or neutral position.
Safety risk
If the ignition is in the run position and the engine starts unexpectedly while the vehicle is being serviced, there would be an increased risk of personal injury.
Remedy
Navistar will notify owners, and dealers will install an overlay harness and relay to provide electrical power to the starter circuit, instead of using the BCM to provide power. This repair will be performed free of charge. The recall began September 12, 2019. Navistar's number for this recall is 19512.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Vehicles covered by recall 19V534000
| Make and model | Model years |
|---|---|
| Ic Bus Cesb | 2020 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.