NHTSA Recall 18V695000: Electrical system: wiring
Yamaha Motor Corporation, USA reported this safety recall to NHTSA on , covering an estimated 4,736 vehicles. It affects 2012–2013 Yamaha XTZ12.
| NHTSA campaign | 18V695000 |
|---|---|
| Manufacturer campaign | 990122 |
| Component | ELECTRICAL SYSTEM › WIRING |
| Report received | October 4, 2018 |
| Owner notification | October 26, 2018 |
| Initiated by | Manufacturer |
Defect
Yamaha Motor Corporation, USA (Yamaha) is recalling certain 2012-2013 Yamaha XTZ12 Super Tenere motorcycles. Over time, a gap may develop in the protective sealant where the lead wires of the accelerator position sensor (APS) and throttle position sensor (TPS) connect to the electronic control unit (ECU). This may cause corrosion on the wires, preventing the engine from returning to idle after the throttle is released.
Safety risk
If the engine does not return to idle when the throttle is released, it can lead to a loss of control, increasing the risk of a crash.
Remedy
Yamaha will notify owners, and dealers will bypass the wire lead connection with a new sub lead harness multi-connector, free of charge. The recall began October 26, 2018. Owners may contact Yamaha customer service at 1-800-962-7926. Yamaha's number for this recall is 990122.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Vehicles covered by recall 18V695000
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.