NHTSA Recall 16V815000: Electrical system: wiring
Kia Motors America reported this safety recall to NHTSA on , covering an estimated 71,704 vehicles. It affects 2008–2009 Kia Sportage.
| NHTSA campaign | 16V815000 |
|---|---|
| Manufacturer campaign | SC138 |
| Component | ELECTRICAL SYSTEM › WIRING |
| Report received | November 10, 2016 |
| Owner notification | December 28, 2016 |
| Initiated by | Manufacturer |
Defect
Kia Motors America (Kia) is recalling certain model year 2008-2009 Kia Sportage vehicles manufactured August 9, 2007, to May 13, 2009. The wire harness cover on the Hydraulic Electronic Control Unit (HECU) may be improperly sealed allowing water to get onto the HECU circuit board. If the water is contaminated with salt, such as could occur from melted snow, the wire harness connector pins may corrode and the circuit board may short circuit.
Safety risk
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Remedy
Kia will notify owners, and dealers will inspect the connector pins for corrosion, if no corrosion is found, the connector cover will be replaced. If corrosion is present, the dealer will replace the HECU assembly and the connector cover, free of charge. The recall began on November 28, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC138.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Vehicles covered by recall 16V815000
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.