NHTSA Recall 14V574000: Exhaust system (engine and engine cooling)
Navistar, Inc. reported this safety recall to NHTSA on , covering an estimated 6,481 vehicles. It affects 2011–2012 Workhorse W62.
| NHTSA campaign | 14V574000 |
|---|---|
| Manufacturer campaign | 61401-C |
| Component | ENGINE AND ENGINE COOLING › EXHAUST SYSTEM |
| Report received | September 19, 2014 |
| Owner notification | November 17, 2014 |
| Initiated by | Manufacturer |
Defect
Navistar, Inc. (Navistar) is recalling certain model year 2011-2012 Workhorse W62 Commercial Chassis manufactured June 21, 2010, to October 2, 2012. In the affected vehicles, the weld joining the right hand side exhaust down pipe to the exhaust manifold may fatigue.
Safety risk
A failure of the weld may allow hot exhaust gases to enter the engine compartment, increasing the risk of a fire.
Remedy
Navistar will notify owners, and dealers will install support brackets on the right and left hand exhaust down pipes and a catalyst spacer bar to prevent swaying. Any cracked down pipes will be replaced. These repairs will be performed free of charge. The recall began on November 17, 2014. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 61401-C.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Vehicles covered by recall 14V574000
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.