NHTSA Recall 11V091000: Equipment
DOUBLE K INC. reported this safety recall to NHTSA on , covering an estimated 175 vehicles. It affects 3 models including the Double K Mainstreet.
| NHTSA campaign | 11V091000 |
|---|---|
| Component | EQUIPMENT |
| Report received | February 11, 2011 |
| Owner notification | February 22, 2011 |
| Initiated by | NHTSA Office of Defects Investigation |
Defect
Double k is recalling certain buses equipped with trans air ta 73 evaporators. The evaporator utilizes a power resistor to regulate blower speed. Should a short occur in the "low or medium speed" circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse.
Safety risk
This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. The overheating can result in a fire.
Remedy
Double k in cooperation with trans air will install a thermal shutdown device in series with the speed resistors. This service will be performed free of charge. The safety recall began during february 2011. Owners may contact trans air warranty and service center at 1-800-673-2446 and double k at 1-715-478-5090.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Vehicles covered by recall 11V091000
| Make and model | Model years |
|---|---|
| Double K Mainstreet | 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007 |
| Double K Villager | 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006 |
| Double K Villager 158 | 2007 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.