NHTSA Recall 10V618000: Equipment
GLAVAL BUS DIVISION reported this safety recall to NHTSA on , covering an estimated 119 vehicles. It affects 4 models including the Glaval Apollo.
| NHTSA campaign | 10V618000 |
|---|---|
| Component | EQUIPMENT |
| Report received | November 23, 2010 |
| Owner notification | December 23, 2010 |
| Initiated by | Manufacturer |
Defect
Glaval is recalling certain model year 2002, 2003, 2006, 2007, and 2008 ford e350/e450 universal, chevy/GMC 4500/5500 titan and freightliner mb-55 apollo transit buses manufactured from august 1999 through july 2007, and equipped with a trans/air ta73 evaporator. The evaporator utilizes a power resistor to regulate blower speed. Should a short occur in the "low or medium speed" circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse.
Safety risk
This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. The overheating can result in a fire.
Remedy
Glaval in cooperation with trans air will install a thermal shutdown device in series with the speed resistors. This service will be performed free of charge. The safety recall began on december 23, 2010. Owners may contact trans air warranty and service center at 1-800-673-2446.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Vehicles covered by recall 10V618000
| Make and model | Model years |
|---|---|
| Glaval Apollo | 2002, 2003, 2006, 2007 |
| Glaval Bus Apollo | 2008 |
| Glaval Titan | 2002, 2003, 2006, 2007, 2008 |
| Glaval Universal | 2002, 2003, 2006, 2007, 2008 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.