NHTSA Recall 10V458000: Cables (electrical system)
TESLA MOTORS, INC reported this safety recall to NHTSA on , covering an estimated 439 vehicles. It affects 2010 Tesla ROADSTER2.
| NHTSA campaign | 10V458000 |
|---|---|
| Component | ELECTRICAL SYSTEM › 12V/24V/48V BATTERY › CABLES |
| Report received | October 1, 2010 |
| Owner notification | October 31, 2010 |
| Initiated by | Manufacturer |
Defect
Tesla is recalling certain model year 2010 roadster 2.0 and 2.5 vehicles equipped with a 12v auxiliary cable. The 12v auxiliary cable for the low voltage back up power system may be improperly routed. If the wire is improperly routed, and trapped against the wheel well cover, the wire may abrade against the edge of the carbon fiber armature and, over time, expose the wire. Contact between the bare wire and carbon fiber may cause a short-circuit leading to possible electrical arching.
Safety risk
Short circuit and electrical arcing could lead to a fire in the right front headlamp area.
Remedy
Tesla motors will check the routing of the 12v auxiliary cable and install a protective sleeve over the wire free of charge. This will prevent misrouting and pinching by the wheel well cover. The safety recall began on october 31, 2010. Owners may contact tesla customer service at 877-888-3752.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Vehicles covered by recall 10V458000
| Make and model | Model years |
|---|---|
| Tesla ROADSTER2 | 2010 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.