NHTSA Recall 09V460000: Service brakes, hydraulic
DAIMLER TRUCKS NORTH AMERICA reported this safety recall to NHTSA on , covering an estimated 602 vehicles. It affects 2 models including the FCCC B2.
| NHTSA campaign | 09V460000 |
|---|---|
| Manufacturer campaign | FL-568 |
| Component | SERVICE BRAKES, HYDRAULIC |
| Report received | December 1, 2009 |
| Owner notification | April 23, 2010 |
| Initiated by | Manufacturer |
Defect
Daimler trucks is recalling certain model year 2008 through 2010 thomas built saf-t-liner c2 school buses and fccc b2 chassis manufactured from october 1, 2007 through august 10, 2009, equipped with cummins isb cm2150 j1939/1587 engine control unit, bosch hydraulic pin-slide front brakes, and webasto 17k btu coolant heater. The front right hand crossover brake line may have been secured using shorter offset than specified clamps potentially allowing the brake line to rub on the surrounding components. This may lead to a brake fluid leak.
Safety risk
Continued contact between the brake line and the surrounding components may lead to a loss of brake fluid and reduce braking performance potentially resulting in a vehicle crash.
Remedy
Daimler trucks will notify owners. Dealers will inspect the units and clamps with shorter offset than specified will be replaced with longer offset clamps. Any brake lines found to be damaged will be replaced. Repairs will be done free of charge. The safety recall began on april 23, 2010. Owners may contact daimler trucks toll-free at 1-800-547-0712.
Notes
Daimler trucks' campaign number is fl-568.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Vehicles covered by recall 09V460000
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.