NHTSA Recall 04V560000: Headlights (exterior lighting)
GENERAL MOTORS CORP. reported this safety recall to NHTSA on , covering an estimated 1,378 vehicles. It affects 2005 Chevrolet Cobalt.
| NHTSA campaign | 04V560000 |
|---|---|
| Manufacturer campaign | 04100 |
| Component | EXTERIOR LIGHTING › HEADLIGHTS |
| Report received | November 22, 2004 |
| Owner notification | November 17, 2004 |
| Initiated by | Manufacturer |
Defect
Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the bulb shields inside of the headlamps can loosen due to vibration.
Safety risk
The bulb shield can loosen or break because of vibration. If this occurred on a headlamp installed in a vehicle, oncoming drivers may notice additional glare, increasing the risk of a crash.
Remedy
Dealers will install two new headlamp assemblies. The recall began on november 17, 2004. Owners should contact chevrolet at 1-800-630-2438.
Notes
GM recall no. 04100.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-DOT (1-888-327-4236).
Vehicles covered by recall 04V560000
| Make and model | Model years |
|---|---|
| Chevrolet Cobalt | 2005 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.