NHTSA Recall 03V383000: Recreational vehicle/trailer (equipment)
JAYCO, INC. reported this safety recall to NHTSA on , covering an estimated 6,442 vehicles. It affects 12 models including the Jayco Cove.
| NHTSA campaign | 03V383000 |
|---|---|
| Component | EQUIPMENT › RECREATIONAL VEHICLE/TRAILER |
| Report received | October 9, 2003 |
| Initiated by | Manufacturer |
Defect
On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
Safety risk
An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
Remedy
Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or jayco at 1-574-825-0608.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-DOT (1-888-327-4236).
Vehicles covered by recall 03V383000
| Make and model | Model years |
|---|---|
| Jayco Cove | 2002, 2003 |
| Jayco Designer | 2002 |
| Jayco Designer Legacy | 2003, 2004 |
| Jayco Eagle | 2002, 2003 |
| Jayco Escapade | 2003 |
| Jayco Granite Ridge | 2002, 2003, 2004 |
| Jayco Greyhawk | 2002, 2003, 2004 |
| Jayco Jay Flight | 2002, 2003 |
| Jayco Kiwi | 2002, 2003 |
| Jayco Legacy | 2002, 2003, 2004 |
| Jayco Qwest | 2002, 2003 |
| Jayco Talon | 2002, 2003 |
Being listed here means the campaign covers the model year, not that every car was built with the defect or is still unrepaired. Enter your VIN above to check your specific vehicle. Recall repairs are free at authorised dealers. Source: NHTSA, October 2026.